RSS Feed

Monthly Archives: August 2014

Sigh of Relief

Posted on

Today went much better than yesterday, all I had to do was stay AWAY from the electrical wiring.  haha  I went back to doing some other things in Junebug that I’m much better at.  I feel like I got a lot done and am feeling pretty good about how things are looking!

It was raining this morning, so I decided to run some errands before getting started.  I needed to return some things to Lowe’s and pick up some new items, plus go grocery shopping.  I finally found the other matching mirror at Target that I had been searching for so that I could install it behind the star cutout in my bench.  I already had one and needed another one.

When I got home, I started working on finishing the benches.  I also bought some spray foam gap filler so I could fill in the holes in the closet where the drains used to be.   I thought about closing the holes some other way, but this seemed like the easiest.   It worked great!  Later I will sand it down and paint over it.

IMG_4879

Here’s the hole where the power inlet used to be.

IMG_4880

These holes were for the sink drain and vent. There were galvanized pipes here, and I promptly did away with those. They were taking up way too much space!

IMG_4882

The hole after spraying some foam into it. It expanded into a bubble, it was kind of funny.

IMG_4899

After it dried, I cut the excess off with a kitchen knife. This stuff works great!

After installing the mirrors behind the star cutouts in my benches, I noticed the mirror was reflecting the backside of the wood, and it wasn’t pretty.  I decided to remove the mirrors and paint the backside purple so it would look better.  Then I reinstalled the mirrors and secured the benches to the floor.

IMG_4891

While the purple paint was drying, I decided to hang the curtains.  You can see them in the above photo, but I’ll post another one here at a different angle.  I think they look so nice against the shellacked wood!

IMG_4911

I also finished adding some wood trim around the window in the kitchen.

IMG_4904

 

My friend, Tracy, gave me this doormat with a J on it.  I’ve been using it for the house, but now I can also use it for Junebug, how perfect!  biggrin

IMG_4894

 

Next, I needed to add some vinyl welt in the seams between the walls and the ceiling.  I was supposed to do this before I attached the ceiling panels, but I totally forgot.  oops  My cutouts for the wall panels weren’t exactly the right size, so I needed to add the welt (similar to the original design) to cover up the gap.  I nailed it in using tiny nails so they weren’t too noticeable.  It isn’t perfect, but I think it looks pretty good and it covers the gap.   I actually found this welt through a boat supplier.  It’s meant for marine upholstery, but it works great for this purpose too!   http://veada.com/marine-vinyl-boat-upholstery/vinyl-welt-cord-piping.html.

 

IMG_4897

Before

IMG_4912

After

IMG_4913

Street side – after

I also added some trim pieces to the door frame.

IMG_4909

Here’s a picture of the exterior street side.  Can you spot the mistake I made cutting the new skin and had to cover up?  I don’t think it looks too bad.  You can see it, but it’s not a glaring mistake at least.

IMG_4916

 

While I was at Target, I picked up a couple of frames for my owl art that I plan to hang in Junebug.  Oh yeah, in case I didn’t mention it before, I’m obsessed with owls and plan to have an owl theme in Junebug. smile

IMG_4918

 

I was really hungry after doing all of the things I just mentioned, so I took a break and made myself a filet mignon with grilled okra and portabella mushroom.  I burned my filet a little because the grill’s fire was too hot.  Luckily, the flavor was still awesome and I thoroughly enjoyed it.  After eating, I got back to work.  I wanted to finish making the bench seats today.

In order to make the seats, I had to take apart the seat backs that I had made back in December.  I wanted to reuse the foam and material since it was so expensive.   I also removed the material from the long seat cushions since I didn’t need those to be purple anyway because they’ll be covered up with bedding.  The foam wasn’t the right size, so I had to cut it and piece together a couple of different sizes to get it to work.   Once wrapped with the batting and material, I don’t think the seam in the foam will be noticeable.

 

 

IMG_4917

Foam cut and ready for the batting.

I discovered that my good serrated kitchen knife worked great to cut through the foam!  I wish I would have discovered that the first time I was making these seat cushions.   Live and learn I guess.

IMG_4919

Batting is stapled down and the cushion is ready for the material.

 

IMG_4920

Adding the material.

 

IMG_4921

Seat cushion is complete!

 

IMG_4922

All the seat cushions and seat backs are now complete! The black cushions in back are the original ones from the camper and will be used for the bed. They are actually pretty comfortable!

IMG_4930

Seat on curb side. I added my Shasta pillow for the full effect. It looks pretty cute!

IMG_4929

Here’s the street side seat. I sat on it to try it out and it’s quite comfy!

Tomorrow, I’m planning to finish the bed and closet, then install the Fantastic Vent if it’s not raining.  If it’s raining, I may only be able to do interior work.  I also need to finish moving the hole in the floor leading to the exterior plug underneath the camper.  This wasn’t an urgent item, but it needs to be done, especially with the electrician coming on Tuesday.

I’m feeling pretty excited now that everything is coming together!  I can’t wait to get more done tomorrow.  smile


 

Let There Be Light!

Posted on

I think there have been a few days where I was really frustrated and wanted to quit, but today takes the cake.  I knew I wasn’t talented at electrical work and today proved me right.  After spending quite a while hooking up all of the new fixtures and outlets last weekend and during the past week, I was ready to finish hooking up the breaker box, power inlet, and ground wire so I could plug the camper in.  I managed to finish the breaker box and shore power inlet pretty quickly, as well as drilling a hole in the floor for the ground wire and attaching it to the frame below the camper.

In order to figure out how to wire the new breaker box in the first place, I consulted my favorite forum, http://vintagetrailertalk.freeforums.net/thread/2368/71-shasta-loflyte-amp-upgrade.  The thread I just linked is one that includes step by step instructions on how to upgrade your standard 15 amp system to a 30 amp.

 

IMG_4865

I followed the instructions from the forum on my iPad while I worked.

IMG_4866

I removed the 60 amp breaker that this box came with and replaced it with two breakers, one 20 amp (left) and one 15 amp (right).  In this pic, I have already connected the 20 amp circuit to the breaker.  It will feed the lights and outlets inside the camper.

IMG_4867

In this picture, I have connected the 20 amp circuit (seen on bottom of pic) and the shore power inlet. I used 10 gauge wire for the shore power inlet and 12 gauge for the other wiring.

IMG_4869

And here’s the box with the last circuit installed that will go to the external outlet for the AC (and twinkle lights :)). Since the AC draws 7 amps of power, I thought it would be best for it to run on its own circuit.   You can see that I used a jumper wire to complete the circuit from the 20 amp to the 15 amp breaker. I used 10 gauge wire for the jumper wire.

After connecting all of the circuits, I went outside to hook up my shore power inlet.  I had to buy another hole saw for the job.  Not sure what I’ll do with these hole saws when I’m done!  I ordered my stainless steel 30 amp power inlet from http://www.vintagetrailersupply.com/.  I looked around online and they actually had the best price on these.  I also ordered a 30′ cord to connect to the shore power plug at the campground.  Both of these items are made by the same manufacturer, Furrion.  The cord even has an LED light on the end near the plug to indicate if polarity is reversed.  If it’s lit blue, that means the trailer is wired correctly and if it’s red, that tells you that the electrical current is not running as it should be, which is probably due to incorrect wiring.    I thought this was handy seeing as how there was a good chance I did something wrong on the trailer wiring!

IMG_4870

Here’s my stainless steel power inlet and the 2 3/4″ hole saw I needed to make room for it.

IMG_4871

Hole is cut and ready to install power inlet.

IMG_4874

All installed! It’s nice a shiny, just like Junebug’s skin!

IMG_4873

Here’s the interior pic of the power inlet. I accidentally removed a little too much of the sheath over the wires, so I added a bit and taped it down, just for added protection. I’m pretty sure it will be fine but I wanted to be safe. I used screws that were a little too long and they poke through the wall, oops. Luckily this will be hidden by the bed anyway.

IMG_4872

I used some insulated staples to secure the wires.

IMG_4875

The final task was to connect the ground wire (seen in green). I drilled a hole through the floor and ran it down below the camper and wrapped it around a bolt attached to the frame.

After hooking everything up, I was ready to plug it in!  I was so nervous that my knees were literally shaking.  I don’t like to mess around with electricity.  I went in the garage and plugged in the end of the cord.  I went back over to the camper and didn’t see that the light had come on.  I stupidly went to the fixture and pulled the chain.  It shocked me! eek  And.. it didn’t turn on.  ugh  I went back and unplugged the cord.   So disappointed…  I got online and posted some pictures on Vintage Trailer Talk to see if anyone could help me.  I also chatted briefly with a guy who works at RV Masters here in Houston to see if he could help me troubleshoot.  We both agreed it was either a problem with the ground or there was a piece of hot wire touching something.  I went back outside to check all my connections.  I disconnected the light fixture above the bed and then noticed that my ground wires had come loose inside the j-box near that fixture.  I reconnected those and everything worked!  I unplugged the cord again and reconnected the light fixture above the bed.  When I plugged it back in, everything wasn’t working.  ugh  Back to square one!  After at least an hour of messing with it, I realized that one of the hot wires inside the fixture was exposed and was touching the ground wire.  This was causing the whole fixture to be live.  Once I fixed that, everything was working again, yay!

I screwed a light bulb into the fixture above the sink and it worked!

IMG_2460

Then I went back to the troublesome fixture above the bed.  I put it back together and screwed a light bulb into it.  I went back out to plug in the cord, and when I returned it was on!!

IMG_2461

Unfortunately, even though it was working, the stupid fixture and the j-box next to it were electrified when I touched them with my voltage sensor.  ugh.  At this point, I was fed up.  I called the guy from RV Masters, and he said he could come by next week with his electrician to take a look at it.  I can probably fix it, but I’m wasting a lot of precious time on this when I need to be finishing up other items!

I’m so disappointed that I couldn’t get this all working perfectly on my own.  I’m so close I can taste it!  That being said, I really don’t want to hurt myself or my camper.  I’d better leave it to the professionals.

After giving up on the electrical, I finished a few trim pieces around the kitchen window and secured some smaller pieces of countertop that go around the stove.  I also hung some curtains in one of the windows.  I didn’t get pictures of these two things.  I guess I was too annoyed about the electrical work not to mention I was running out of daylight.   I think the curtains are going to look really cute in there!

Here’s the list of everything I still have left to do before the party (in no particular order).  The list looks relatively short, but I know how long it takes me to do things so I’m sure it will take me right up until the party to get these things completed.   I hope I can do it!  I’m starting to feel the pressure..

  • Install mirrors in benches (behind starburst cutout)
  • Secure bed and benches to floor
  • Make cushions for benches
  • Finish painting closet and patch holes
  • Get electrical system working properly (electrician will take care of this!)
  • Install Fantastic Vent
  • Paint tongue and bumper (maybe wheels too if time), also paint propane tank
  • Install Shasta emblem and other little emblems as well as door catch
  • Finish installing vent for AC to go on cabinet face
  • Install baggage door
  • Polish wings and reinstall
  • Seal cracks and staples on exterior with gutter seal
  • Finish hanging curtains and add other decorative items

Tomorrow is a new day and I’m not going to let my electrical system woes get me down.  I will ignore that for now and get busy on the other items.

 

 

Determination

Posted on
Determination

I can’t remember what life was like before Junebug.  What did I do with all of my time??  Sure, I had other hobbies, but I didn’t do anything nearly as obsessively as I work on this project.  It’s kind of like trying to imagine my life before the internet or my iPhone. haha  Maybe I was just relaxing more or perhaps watching more movies.  

Both of my neighbors admitted yesterday that they doubted me in the beginning and didn’t think I could do this project on my own.  Little did they know, I am a very determined person, and when I put my mind to something, I will do it no matter what!   One of my neighbors also said that I had done a good job for a girl.  rolleyes  That offended me, and I told him so.  He then backtracked and said he meant that he didn’t think there were many girls who would take on this sort of project.  He might be right, but I’m hoping maybe some other women who aren’t sure about doing something like this will come across my blog and see that they can do it!  All you need is time, money, and a lot of determination. 

This weekend, I got a lot done, but I still didn’t completely finish my electrical system like I had planned.  I had no idea how difficult 12 gauge wiring was going to be to deal with.  I still feel pretty good about where I’m at, although I’ve only got two weekends left until the unveiling party, so I am a little worried about time.  I will probably have to work on a few things during the week just to be sure I finish in time!  Luckily, my next two weekends are three day weekends, so that really helps.

I think I mentioned in my last post that I had lost my keys.  Wouldn’t you know, they were hanging on a nail in the garage the whole time!  I have become so disorganized with this project, this is unlike me!  I now have a little camper key cover on my keys.  Maybe this will help.  If nothing else, it’s cute. smile

IMG_2446

I was off on Friday, so I got up early and started working on finishing the exterior of Junebug to get her ready to take to Oscar’s shop to finish the bumper and spare tire mount.  I had to finish stripping the paint off of the drip rail, and of course, it took forever!  I don’t know how that paint was so stuck on there.

After doing that, I polished the eyebrows and installed them over all of the windows.  

IMG_4841

Before

IMG_4842

After

 Oh, by the way, I’m not going to post any more full exterior or interior pictures until after my unveiling party on September 12th.  I don’t want to ruin the surprise for my friends who will be coming to the party and also read this blog.  For anyone who can’t make it to the party, sorry, but I promise to post lots of pictures after that!  

It took me most of the day on Friday to finish up the exterior, and around 6pm, I started getting Junebug ready to go to Oscar’s shop.  I noticed that my jack had become really hard to turn.  I got the camper out of the driveway and hooked up to my car, but I couldn’t get the jack to go back up so I could get on the road.  Apparently, it had decided to break on me. grr  My nice neighbor came to the rescue, and he helped me remove the jack and put it in my car.  I went on my way to Oscar’s place to see if he could help me with it.  Once I arrived at Oscar’s shop, he immediately got ot work on my bumper with his son and his friend as his assistants.   I got really nervous with the welding so close to my beautiful pre-polished aluminum skin.  That stuff scratches so easily!!  They put a few new scratches in it, but in the end, it turned out fine.  I snapped a couple of photos while they weren’t looking. hehe

IMG_2441IMG_2438

 

I’ll wait to post a pic of the finished bumper with the spare tire mount.  It still needs to be painted, and I want to wait until after the unveiling to show it off anyway.  

I noticed that my side running lights and license plate light didn’t work properly when plugged into my car.  I was really worried I had wired them wrong, but when Oscar hooked Junebug up to his two vehicles, everything worked great!  

Since it was late on Friday when I took Junebug to Oscar’s place and my jack had quit working, I decided to leave her overnight at his shop and pick her up in the morning.  On Saturday morning, I took my VW to Master Hitch since that’s where I got the wiring installed, and they said everything was working perfectly in it.  ugh  I guess I’m going to have to take my VW and Junebug to Master Hitch because it doesn’t seem like the problem is my camper.  Luckily the most important lights are working, the brakes and blinkers.   I went ahead and bought a new jack while I was at Master Hitch, and Oscar installed it for me.  It only cost $29, so that was a relief.  It works great too!

IMG_4844

 

I’m planning to paint it when I finish painting the hitch.  I can’t decide if I want to paint it silver or purple.  

On the drive home from Oscar’s shop, I noticed Junebug was swaying a little bit.  She didn’t sway at all before, so I’m wondering if it’s the new bumper and spare tire.  I had to install the spare tire to the side in the rear so it wouldn’t cover up the license plate.  I’m thinking this is messing up the weight distribution.  Hopefully by the time I install the propane tank and fill up Junebug with stuff, it will all even out.

After getting home on Saturday, the first thing I did was install the two holes for the AC.  I wanted to finish wiring the receptacles inside the camper, but I knew it would be way better to do that with the AC on!  

I got my AC from ClimateRight.  It’s an 8200 btu unit that is AC only, no heat.  A little space heater warms up Junebug just fine, so I didn’t need a heater.   This little AC sits outside the camper and connects via two hoses that are actually the hoses you would use for a dryer exhaust.  Their website said to install the two holes for the hoses on the side of the camper, but I thought that would be ugly.  I decided to drill two holes in the floor underneath the kitchen cabinets for my intake and output.  I haven’t finished making it look pretty yet, but it’s working great!  I got this kind because a window unit would look ugly (in my opinion) and Junebug’s frame isn’t strong enough to support a roof unit.  Other people have installed a window unit under the bed and vented it through the baggage door or through the floor, but I didn’t really want to go that route either.  This seemed like the best option for me, and so far, I’m happy with the decision.  It has a little infrared remote control that serves as the thermostat so it knows the temperature inside the camper at all times.  

IMG_4846

I had to buy a hole saw and the attachment to go with it. It cost around $40 for both so it wasn’t cheap!

IMG_4849

One of the holes I had to cut was going to go through the old asbestos tile. I was a little nervous about this, so I wore my mask and kept spraying the floor with water while I was cutting. I then carefully gathered up all of the shavings after I was done.

IMG_4847

The one on the right will be under the fridge when I put it back in its spot. It’s for the output. The one on the left will be the return air vent, which is under the sink.

IMG_4848

Here’s a pic of the one on the right after I drilled the hole and put the attachment in it.

IMG_4851

And both are installed! I added some ductwork to the output and a screen to the return to keep particles out. The ductwork is a little too long since I will be putting a piece of wood back in the space below the fridge. I am still trying to decide how to cover the space and have a vent. None of the vents at Lowe’s were exactly what I was looking for.

IMG_4852

Here’s the unit hooked up outside. I am going to find a base for it with little wheels. I also need a way to secure it to the hitch so someone doesn’t steal it from the campground. I will worry about those things a little later.

Once I got the AC hooked up, I got to work on the electrical.  Unfortunately, it was late in the day, so I didn’t really get anywhere.  I made more progress today. 

I ended up deciding to replace both the fixture and the fixture box above the dinette.  I didn’t like the idea of having the plug on the fixture itself like the original, it didn’t seem as safe.  The wires in the original fixture were old too.  The only thing I don’t like about the new fixture box is that it’s blue, and you can see the top of it when standing over by the kitchenette.  I may go back and replace it with a different one later, I don’t know. I also had to add a j-box between the outlet and the fixture above the dinette and pigtail the wires from the outlet.  It was too difficult to get two sets of 12 gauge wire into the little outlet box because it’s so thick.  I also had so much trouble accessing the boxes in this space because the ceiling is curved.  

IMG_4854

Before connecting the wires inside the j-box. The old fixture box is still here.

IMG_4856

With new j-box and wires all connected and stapled down. I really hope this works when I hook it up to power!

The 12 gauge wire was so difficult to work with!!  It took me forever to hook up each receptacle thanks to the 12 gauge wire.

After finishing the dinette, I installed the outlet under the sink for the fridge.  It was an easier one because I only had one set of wires connected to it since it was the end of the circuit.  

IMG_4855

I then moved over to the closet.  I wanted to add an outlet here for general use, but also because I ran the 12v wires from the Fantastic Vent over to this area.  I bought a voltage converter and a plug so that I can plug the Fantastic Vent into a normal outlet(it comes in 12v only).  Later down the road, I plan to upgrade my system to include a battery so that I can have electricity off grid.  That’s too much to take on right now though, so I’m just hooking up the fan this way for now.

IMG_4859

I bought some fancy new wire cutters, specifically made for stripping 12 and 10 gauge wire. They really made my life a lot easier.

 

IMG_4860

Here’s the closet receptacle. I bought a double outlet box so I would have room for the wires to the side. I put a cover over this so you can only see the outlet now.  I will also be painting the box and area around it purple.

And the pictures below are the fixtures all hooked up again!  

 IMG_4861IMG_4862

I also installed an outdoor plug underneath the camper to plug my AC into.  It has its own dedicated circuit (15 amps).  It only draws 7.2 amps, but I wanted to be on the safe side and let it have its own.  I accidentally picked a spot for the outdoor plug that was too tight initially, so I had to move it, and in doing so, I exposed some of the wire (rated for interior wiring only).  I may need to go back and redo it later.  I’m going to leave it for now because I have so many other things I need to finish first.

The pictures below are the underside of the camper.  On the left, you can see the outdoor plug I installed.  Above that is the air vent for the AC.  It didn’t come with a cap, and I really needed one, so I was excited to find this adjustable cap at Lowe’s.  It expands when you turn the wing nut so that it fits snug inside the opening.  I bought two of these to cover the holes where the AC hoses connect when it’s not in use.  They worked perfectly for this task!

 

 

 

IMG_4864 IMG_4863 

All that’s left of the electrical system is the power inlet and the breaker box with corresponding wiring.  I also need to run a new ground wire.  I ran the old one and bolted it to the frame, but it’s a really high gauge and won’t work for my new system.  I bought a piece of 8 gauge wire to use for the new ground wire, so I’m going to have to fish it down to the frame, hopefully using the old piece.  If that doesn’t work, I may just drill a hole through the floor and run it to the frame that way. I hate to drill more holes in the floor though, I think I may have reached my quota! 

Hopefully I’ll have some time during the week to finish installing the breaker box and inlet, otherwise I will start out next weekend a little behind schedule.  We’ll see how it goes!   Two weeks to go until I need to be finished…deep breaths…. 

 

 

Crunch Time!

Posted on

I just sent out the Evite for Junebug’s unveiling party this past week.  Evite even had a little Shasta camper template so it couldn’t have been more perfect for the event!  The date is September 12th and now the pressure is on to finish.

I thought since I now had September 12th as my new deadline, I would get extra done this weekend, but that’s not really how things went.  On Saturday, I applied a third coating of paint stripper to the drip rail.  I let it sit and went in the garage to finish rebuilding the door.  I thought the door wouldn’t take me that long to finish because I finished stripping the paint off the frame pieces during the week.  Unfortunately, it took me almost all day!  I initially thought it would be a good idea to add some putty tape around the edges of the door frame to seal it.  That didn’t work at all.

IMG_4829

 

What ended up happening was that the putty tape was too thick and I couldn’t get the frame piece around it because it’s supposed to fit tightly.  Then I tried some gutter seal, and that just made a big fat mess everywhere, so I gave up and didn’t add any sealant.  If some water gets in there, oh well.

Once I was done rebuilding the door, I got ready to install it.  I first put the screen door back in the door frame because it was still attached to the hinge.   It was at that time that I noticed the screen no longer fit in the doorway!  When I retiled the floor on top of the old tiles, it added just enough extra height to the floor that the screen was too long.  ugh  I was planning to make a new screen door one day, so I guess that day will come sooner than I imagined!

I removed the screen door and then installed the door.  After I found the handle for the exterior and interior, I went to look for the keys and then realized I had no idea where they were.  I searched high and low and still haven’t found the stupid keys!  I usually don’t lose things, but this project has made such a mess of my garage and house that I have been losing things right and left.  I went ahead and installed the handle, but now it won’t lock unless you’re inside the camper.  I may have to pay to have it rekeyed…again.

Later that day, I tried scraping off the remaining paint from the drip rails.  Unfortunately, some of the paint would not budge.  I ended up deciding to use the wire wheel on it to scrape the rest off.  It leaves scratches all over the aluminum, but I was too tired of messing with it.  Even using the wire wheel, it is taking me ages to get all the paint off!  I still have two more pieces of drip rail to go before they’re all cleaned and ready to install.

Today (Sunday), I installed the drip rails that were finished and ready.  I also spent an hour at Lowe’s looking for various pieces I needed to get my AC installed correctly.  I had to get a bit creative, but I’ll save that post for another day.  smile

After installing the drip rails, I also installed the license plate.  It is really starting to come together!  I’m still a little nervous that the tail lights won’t work when I hook them up again.  Fingers crossed that none of the wires come loose under all the skin!

IMG_4837

The lines don’t exactly match up on the left side of the door for some reason. It’s not that noticeable so I’m hoping no one will see it. I’m definitely not taking the door off and starting over!

IMG_4836

Awning rail installed! There’s one screw sticking out a little because I ran into a screw behind it that was holding the frame together. I think I may cut this screw short so that there’s still a screw in that hole.

It’s really starting to look like a complete camper again!

IMG_4839IMG_4840

 

I’m going to try to work on the electric wiring during the week this week just to get a bit of a head start on the weekend.  My new 30 amp plug and cord came in the mail today, but I’m still waiting for the 15 amp adapter that I will need to test it out at home.  I still need to finish installing the breaker box and all of the receptacles first anyway.  Next week’s post should be electric!  hehe

Light at the End of the Tunnel

Posted on

I’m finally able to see the finish line!  I still have quite a few things to do before I’m totally done, but I can finally look at the list of things left and not feel overwhelmed.

I took last weekend off because I went to my grandma’s near Austin and spent time with my family.  My brother and sister in law drove down from Kansas with their two kids and my parents were there as well. I don’t get to see all of my immediate family together very often, so I really enjoyed spending time with them.  The picture below is the morning sun rising over the lake from my grandma’s boat dock.  Pretty nice scenery to wake up to!

 

IMG_2006I came back from my grandma’s feeling refreshed and rested.  I had a busy Monday and Tuesday at work, but toward Tuesday afternoon I starting feeling a little sick.  By Wednesday lunchtime, I had to go home and was stuck there for the rest of the week thanks to whatever illness I had contracted.  I don’t know how I managed to get sick right after a nice relaxing weekend.  confused emoticon

By this weekend, I was finally feeling better, so I slowly got back to work on Junebug.  Even though I got off to a slow start, I did finally end up making quite a lot of progress.

First, I went by a metal fabricator in town to see if they could make some new pieces for the door frame out of my pre-polished aluminum skin I had leftover.  They said that they could, but unfortunately it would cost me around $400.   Yikes!  I decided I would pass.  I then spent several hours trying to fabricate my own pieces.  They looked pretty good, but today I made up my mind that I’m just going to strip the paint off the old pieces and polish them.  It was too hard for me to get the new pieces to look exactly how I wanted.  Oh well..

I finished the wood part of the new door this weekend.  First, I needed to glue a few more support pieces to the frame.

IMG_4783

 

I then shellacked the interior part of the door.  It’s going to look so pretty!

IMG_4785

Natural without shellac

IMG_4786

After one coat of amber shellac

IMG_4805

After 3 coats of amber shellac and 3 coats of clear shellac

I then stripped the paint off of the hinges to the door and screen door.  I still need to polish them so they shine like the new skin.

While I was stripping paint, I also started stripping the paint off of the drip rails and the baggage door.  I had to pull all of the old skin out of the garage so that I could actually find the stupid drip rails.  They were buried under all of the crap in my garage.  I can’t wait until I can clear it all out and actually park my car in it again!

IMG_4803

Pile of old skin. I think I’ll take this to the metal salvage place when I’m done to see how much money I can get for it. Some of the pieces are still good but others, not so much. There’s no way I could sell it to someone for their camper.

IMG_4802

I chopped up some of the old pieces of wood I won’t be reusing and am putting them in the garbage. I had to get rid of some of the clutter in the garage.

IMG_4801

Here are the drip rails – paint stripping in progress

I will have to coat the drip rails again with more paint stripper next weekend and scrub them.  I’m hoping one more coat will do the trick.

IMG_4818

Still a little paint left but I got most of it.

IMG_4819

It was hard to get the paint out of the awning rail so I might end up just leaving a little there. I don’t think it will be that noticeable.

IMG_4820

There were already some scratches on the baggage door, so I went ahead and scratched it some more with my wire brush while I was getting the paint off. It will just have a nice brushed aluminum look!

 

Next, I cleaned the jalousie windows, polished them, and then installed.  They turned out really nice!

It was so hot outside, I decided to do the window cleaning inside.  I turned my bathtub into the cleaning area.  It made quite a mess, but I cleaned it all up later.  I got most of the grime off but the window screens are still rusty.  I figured I can replace those at some point if it bothers me.

 

IMG_4779

 

I was really pleased with how shiny I was able to get the jalousie windows!

IMG_4784

 

Before installing the window, you have to apply putty tape around the back edge of the window to seal it water tight.  After screwing it down, I came back and cut the excess with a razor blade.  Fingers crossed it sealed properly!  I don’t want any leaks in my “new” camper!

 

IMG_4788

IMG_4789

 

I also started peeling back a little more of the protective film.  I needed to remove it from the window before installing and then I guess I got carried away.  smile emoticon  I also finished installing the taillights.  I haven’t checked them again to make sure they work.  I hope one of the wires didn’t come loose when I was securing the covers or something horrible like that.

IMG_4794

IMG_4791

 

After installing the windows, I moved inside and finished making the bed and benches (mainly the benches).

IMG_4804

Finished making the frames for the benches.

I already did one cutout a while back, so I just needed to finish the cutout for the other bench.  I used my oscillating tool to cut out the shape after tracing it onto the wood.

IMG_4800

And after applying 3 coats of amber and 3 coats of clear shellac, they’re all done!  Now, I just need to finish making the cushions for the tops and secure the benches to the floor.   I laid down on the bed today to see what it felt like and it was pretty comfortable!  I can’t wait to spend the night in Junebug again!

IMG_4822

I still need to add the mirror behind the starburst cut out.

IMG_4827

 

Next weekend, I will be connecting all the new wiring and hopefully hooking it up to some electricity!  I really hope I don’t burn down my camper in the process.  I will be doing quite a bit of studying online before connecting anything to a power source, that’s for sure!

I’ll leave you with a cute picture of my cousin Anderson and Baxter.  He loves Baxter so much and tells everyone that Baxter is his dog that I just keep for him.  He’s such a sweet kid. smile  I’ve promised him that we will camp out together in Junebug as soon as she’s finished.  He’s excited and so am I!


IMG_2245